Opel Kadett E

1984-1991 of release

Repair and car operation


Opel Kadett E
+ 1. The maintenance instruction
+ 2. Weekly checks and service in a way
- 3. Maintenance service
   - 3.1. Maintenance service of cars with petrol engines
      3.1.1. Operational materials and liquids
      3.1.2. Refuelling capacities
      - 3.1.3. Periodicity of service
         - 3.1.3.1. Each 15 000 km
            3.1.3.1.1. Replacement of oil and the oil filter
            3.1.3.1.2. Replacement of spark plugs
            3.1.3.1.3. Check of tightness of hoses and вытекания liquids
            3.1.3.1.4. Check and replacement auxiliary drivers belts
            3.1.3.1.5. Check of system of ignition
            3.1.3.1.6. Adjustment of turns of idling and quality of a mix
            3.1.3.1.7. Clearing of the filter of the fuel pump on models with the carburettor
            3.1.3.1.8. Level check трансмиссионной liquids
            3.1.3.1.9. Check of a condition of oil
            3.1.3.1.10. Electroconducting check
            3.1.3.1.11. Check brake колодок and a brake disk
            3.1.3.1.12. Adjustment of a manual brake
            3.1.3.1.13. Exhaust system check
         + 3.1.3.2. Each 30 000 km
         + 3.1.3.3. Each two years
         + 3.1.3.4. Each 60 000 km
   + 3.2. Maintenance service of cars with diesel engines
+ 4. The engine
+ 5. System of cooling, heating and ventilation
+ 6. Fuel and exhaust systems
+ 7. Start and gymnastics system
+ 8. Ignition system
+ 9. Coupling
+ 10. Transmissions and power shafts
+ 11. Brake system
+ 12. A suspension bracket and a steering
+ 13. A body
+ 14. Electric schemes


944881c0

3.1.3.1. Each 15 000 km

3.1.3.1.1. Replacement of oil and the oil filter
THE GENERAL DATA

Periodic replacement of oil and the oil filter – the most important preventive procedure of maintenance service. When engine oil grows old, it becomes liquid and polluted that conducts to premature deterioration of the engine.

Before the beginning of this procedure gather all necessary tools and materials. It is necessary, that the engine was warm that oil flew down together with a great bulk of substances polluting it is better.

PERFORMANCE ORDER
1. Uncover with маслозаливной mouths.
2. Loosen the a drain stopper approximately on half of turn. Place the container for oil plum under a drain stopper and unscrew a stopper completely. If it is necessary, press a stopper when unscrew that oil did not proceed prematurely.
3. When oil completely will flow down, move the container under the oil filter.
4. Check up a condition of ring consolidation маслосливной stoppers. Wipe all round a drain aperture a rag and reliably screw up маслосливную a stopper into place.
5. Use the special tool to weaken the oil filter, then unscrew his hand.
6. Wipe all traces of oil and a dirt round a place of fastening of the filter. Check up, whether there was a rubber consolidation on the block of cylinders. If it remains, remove it.
7. Grease with a thin layer of engine oil rubber consolidation of the new oil filter and screw up the filter a hand, without using any tools.
8. Establish a wheel and lower the car on the earth.
9. Fill in oil in the engine, using a corresponding grade of oil. Fill in half of necessary quantity of oil and wait some minutes that oil has flown down in the pallet, then continue to fill in oil in the small portions while level of oil will not reach a minimum level on probeе. At addition about one litre oil level will rise to maximum on probeе. Close a cover of a jellied mouth.
10. Start the engine and allow to it to work some minutes. Check up it about leaks of oil round the filter and a drain stopper on the pallet. Keep in mind that the control bulb of pressure of oil can burn some seconds as oil should fill all channels and oil capacities in the engine.
11. Switch off the engine and wait some minutes that oil has flown down in the pallet. Check up level of oil and add, if it is necessary.