Opel Kadett E

1984-1991 of release

Repair and car operation



Opel Kadett E
+ 1. The maintenance instruction
+ 2. Weekly checks and service in a way
+ 3. Maintenance service
- 4. The engine
   - 4.1. Engine OHV (with a camshaft in the block of cylinders)
      4.1.1. A technical characteristics
      4.1.2. Compression check
      4.1.3. The repair operations which are not demanding removal of the engine
      + 4.1.4. The repair operations demanding removal of the engine
      4.1.5. Adjustment of backlashes of valves
      + 4.1.6. A head of the block of cylinders
      4.1.7. Removal and installation of the oil pallet
      + 4.1.8. The oil pump
      + 4.1.9. Mechanism asterisks timing
      + 4.1.10. Pistons and rods
      4.1.11. Removal and flywheel installation
      4.1.12. Removal and installation of support of the power unit
      4.1.13. Removal and installation of a camshaft and pushers
      4.1.14. Removal and installation of a back sealing ring of a cranked shaft
      4.1.15. Removal and installation of a cranked shaft and radical bearings
      - 4.1.16. Check of elements of the engine
         4.1.16.1. Check of a cranked shaft
         4.1.16.2. Survey radical and шатунных bearings
         4.1.16.3. Check of pistons and rods
         4.1.16.4. Check of a camshaft and bearings
         4.1.16.5. Check of asterisks, a chain and the tension mechanism
         4.1.16.6. Check коромысел and pushers
         4.1.16.7. Flywheel check
      4.1.17. System of greasing of the engine
      4.1.18. Removal and engine installation
      4.1.19. Start of the engine after major repairs
   + 4.2. Engines OHC
   + 4.3. Engine DOHC with 16 valves
   + 4.4. Diesel engines 16D and 16DА
   + 4.5. Diesel engines of 1,7 l
+ 5. System of cooling, heating and ventilation
+ 6. Fuel and exhaust systems
+ 7. Start and gymnastics system
+ 8. Ignition system
+ 9. Coupling
+ 10. Transmissions and power shafts
+ 11. Brake system
+ 12. A suspension bracket and a steering
+ 13. A body
+ 14. Electric schemes


944881c0

4.1.16.2. Survey radical and шатунных bearings
THE GENERAL DATA

Typical defects of bearings

Even thus that radical and шатунный bearings are subject to replacement at engine major repairs, they are necessary for examining carefully as they can give the valuable information concerning an engine condition.

Bearing failure can occur because of a lack of greasing, presence of a dirt or other alien particles, an engine or corrosion overload. Irrespective of the reason of failure of the bearing, it should be eliminated, before the engine will repeatedly gather.

At survey of bearings remove them and spread out in the same order in what they have been established on the engine. It will allow to define a corresponding neck of a cranked shaft and will facilitate search of malfunctions.

Alien particles can get to the engine various ways. Metal particles can be in engine oil as a result of normal deterioration of the engine. Small particles together with engine oil can get to bearings and easily take root into a soft material of the bearing. The big particles, getting to the bearing, will scratch the bearing or a neck of a cranked shaft. The best prevention of failure of the bearing for this reason: carefully clear all internal surfaces of the engine and keep them clean at engine assemblage. Frequent and regular replacement of oil with the filter Is recommended also.

Insufficient greasing of necks of a cranked shaft can be caused the different reasons, such as an oil heat, an overload of the engine and oil leak.

The manner of driving by the car also influences durability of the bearing. Completely open throttle заслонка at low turns of the engine creates high loading on bearings and expression from a zone of contact of an oil film. These loadings lead to occurrence of cracks in a working part of the bearing that weakens the bearing and can lead to a separation of an antifrictional layer from a steel basis.

Movement on short distances leads to corrosion of bearings because the engine does not leave on the stabilised working temperature at which water steams and corrosion gases leave. These steams and gases, being condensed in engine oil, form acid and a deposit. Acid together with engine oil gets to bearings, and corrosion of bearings begins.

Wrong selection of bearings at engine assemblage also leads to failure of bearings. The bearings established with a preliminary tightness, leave an insufficient working backlash of the bearing therefore decreases or there is no butter layer for greasing.